Safety Data Sheet (SDS)

SECTION 1 - IDENTIFICATION

Product Identifier: QUICK CLEAN

Recommended Use: Stripping Paint Emergency Phone: (613) 123-4567 Supplier’s Name: Acme Paint Company Address: 123 Memory Lane, Ottawa, ON T6A 3Y5 Product Use: Paint Stripper

Prepared By: Acme Paint Technical
Phone: (613) 123-4567
Preparation Date: April 01, 2015

SECTION 2 - HAZARDS IDENTIFICATION

DANGER: Poison. May be fatal or cause blindness if swallowed. Eye and skin irritant. Vapor Harmful. Use only with adequate ventilation to prevent buildup of vapors.

Routes of Entry:
Skin Contact: Yes Absorption: Yes
Inhalation: Yes Ingestion: Yes

Effects to acute exposure to product: Methylene Chloride has been known to cause central nervous system damage, depression, blurred vision, blindness and cancer.

Effects to chronic exposure to product: Methylene Chloride has been known to cause liver damage.

SECTION 3 - COMPOSITION / INFORMATION ON INGREDIENTS

Hazardous Ingredient % CAS Number LD 50 of Ingredient (specify route, apecies) LC 50 of Ingredient (specify route, species)
METHYLENE CHLORIDE 39 67-56-1 5628 MG/KG (oral, rat) 83200 PPM (vapour, rat)

SECTION 4 – FIRST-AID MEASURES

Inhalation: Remove to fresh air. Get medical help if there is any breathing difficulty.

Ingestion: If swallowed, induce vomiting. If conscious & alert, give 2 glasses of water. Seek medical attention immediately.

Skin contact: Remove contaminated clothing (incl. shoes) and wash before reuse. Flush with large amounts of soap and water. If irritation persists, seek medical attention.

Eye Contact: Flush eyes with large amounts of lukewarm water for 20 minutes, while holding eyelids open or until irritation subsides. If irritation persists, seek medical attention.

SECTION 5 – FIRE-FIGHTING MEASURES

Flammability: Yes under which conditions: Flammable Liquid
Flashpoint and Method: 11°C, closed cup Autoignition Temperature: Not Available
Lower Flammable Lt (% by volume): Not Available Upper Flammable Lt (% by volume): Not Available
Means of Extinction: Alcohol Foam, Carbon Dioxide, Dry Chemical Powder, Polymer Foam
Explosion Data -Sensitivity toimpact: No Explosion Data -Sensitivity to StaticDischarges No

Hazardous Combustion Pdts: carbon monoxide, carbon dioxide, formaldehyde

SECTION 6 - ACCIDENTAL RELEASE MEASURES

Leak & spill procedure: Wear adequate protective equipment and eliminate all ignition sources. Contain spill with absorbent material and place in a suitable covered and labeled container for disposal.

SECTION 7 - HANDLING AND STORAGE

Handling procedures equipment: Use in well ventilated area. Do not use with incompatible substances and keep away from heat and all ignition sources. Use grounded and non-sparking equipment only.

Storage requirements: Not Applicable

SECTION 8 - EXPOSURE CONTROLS / PERSONAL PROTECTION

Engineering controls (specify such as ventilation, enclosed process): Ventilation to keep exposure below the TLV’s of the hazardous ingredients.

Personal Protective Equipment: Type:
Gloves: Yes Butyl Rubber
Respirator: Yes Niosh Approved
Footwear: No
Eye: Yes Splash Resistant
Other: No

SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES

Physical State: Liquid Odour and Appearance: clear colourless liguid, chloroform-like odour
Coating VOC (gm/l): 491 Odour Threshold (ppm): Not Available
Specific Gravity: 1.22 Vapour Density (air=1): Not Available
Coefficient of water/oil distribution: Not Available Vapour Pressure (mmHg): Not Available

SECTION 10 - STABILITY AND REACTIVITY

Chemical Stability: Stable Unstable under which conditions: Not Available
Incompatibility with other substances: Yes If yes, which ones: If yes,which ones: Strong Acids & Strong Oxidizing Agents
Reactivity & under which conditions: Heat, ignition sources Hazardous Decomposition Products: Not Available

SECTION 11 - TOXICOLOGICAL INFORMATION

Exposure Limits (value, units, by): Methylene Chloride: 200 ppm ACGIH

Irritancy: Not Available Carcinogenicity: Yes, Methylene Chloride causes cancer in laboratory rats.
Reproductive Toxicity: Not Available Synergistic Products: Not Available
Mutagenicity: Not Available

SECTION 12 - ECOLOGICAL INFORMATION

Not a Marine Pollutant under the Transportation of Dangerous Goods Regulations

SECTION 13 - DISPOSAL CONSIDERATIONS

Waste disposal: Check with Federal, Provincial and local government regulations and requirements for disposal.

SECTION 14 - TRANSPORTATION INFORMATION

Shipping Name Class UN# Packing Group
Methylene Chloride 2.1 UN1912 Not Applicable

SECTION 15 - REGULATORY INFORMATION

WHMIS: Class B, Class D1 This product has been classified in accordance with Canada’s Controlled Products Regulations and this MSDS contains all the information required by those regulations.

SECTION 16 - OTHER INFORMATION

Revision history: April 01, 2015

Disclaimer:

Necessary measures have been taken to ensure the accuracy and reliability of the information contained in this SDS, however Acme Paint Company makes no representation or warranty in connection therewith. Acme paint Company disclaims any liability or responsibility for loss or damages resulting from the use of the information contained in this SDS.